The Vanagon 1986-92 was upgraded with a larger 2100cc engine in 1986 and the next major visible change came in 1988 with aerodynamic bumpers, body skirts, aerodynamic head lights, mag wheels and the like. The following are parts specific to this vehicle Note: Most everything is common to the Syncro of the same year with a few minor exceptions such as transmissions, front drive shafts, shocks, front exhaust pipe, springs, etc.
Vanagon 1986-92 2100cc Gas Cylinder Heads 2.1
Cylinder Heads are available new, remanufactured and used. Each can provide years of service.
Wasserboxer
Complete gasket set
......................#SN1509.........$159.95
Head gasket set
.....................#SN1512............$89.95
Crank shaft, Bearings & Flywheel
Rear crank seal (all)
........................#SN1221..........$14.95
Front crank seal
.......................#SN9222...........$9.95
Con. rod bushing
......................#SN11342............$17.95
Main bearing set (std.)
.......................#SN10238.....$94.95
Rod bearing set (std.)
........................#SN1242..........$16.95
Piston Sets with Rings 1.9
Piston set w/rings (std.)
.......................#SN5866.......$349.95
Valve Train
Cam follower
........................#SN1266..........$19.95
Cam bearing set
.....................#SN1608 (X 2).....$14.95
Push rod tube
..........................#SN4524......$12.95
Push rod tube seal,
Inner.................#SN10118..............95
Outer...................#SN1275..............70
Intake valve guide silicone bronze O/S
........................#SN12535..........$4.95
Exhaust valve guide silicone bronze O/S
..........................#SN1138..........$6.95
Intake valve,
.......................#SN11343........$14.95
Exhaust valve
........................#SN11344.......$39.95
Oil Filter & Oil System
Oil filter, K.P.
........................#SN12899............$6.99
Oil Pump (all)
.......................#SN1304..........$22.95
Did you know that Vanagons had a top crash rating and are considered very safe?
Cooling Systembr />
Coolant level sensor, at expansion tank
..........................#SN9066..................$15.95
Exp. tank............#SN14981.................$39.95
Cap.....................#SN9225..........$8.60
Fuel Filter & Fuel System
Fuel filter, in-line, Bosch
..........................#SN5072........$17.95
Electric fuel pump
........................#SN3439......$249.95
Fuel pump relay
.......................#SN15734...................$10.95
Fuel injector
.........................#SN9624.......$89.95
Fuel press regulator
.......................#SN33359.........$60.00
Thermo time switch, at thermo housing, Used
........................#SN35232..................$25.00
Air Filter & Intake System
Air filter..............#SN1392.........$14.95
Emission Control Components
Oxygen sensor OEM
........................#SN9073.......$144.95
Bosch,Universal, (3 wire)
........................#SN3404....................$79.95
Clutch Components
Clutch kit, 228mm
.......................#SN5878........$179.95
Clutch disc, 228mm
.......................#SN1468.........$79.95
T/O bearing
.......................#SN1494...........$24.95
Pilot bearing
.......................#SN5050.............$8.95
Engine Mounts
Inner................#SN1617...........$14.95
Outer................#SN1618..........$13.95
Manual Transmission
Front seal, all.......#SN1852............$3.00
Gasket set...........#SN4538...................$59.95
Front Brake & Hydraulics
Front brake rotor
.........................#SN5814........$59.95
Front brake rotor Rec.
.......................#SN34814........$30.00
Front brake pads
........................#SN2346..........$34.95
Front bleeder screws
.........................#SN2330.............$2.95
Front Bearings & Seals
Front inner wheel bearing
........................#SN9626..........$17.95
Front outer wheel bearing
.......................#SN10413..........$14.95
Front wheel seal, 2 req.
.........................#SN1970.....................$6.95
Steering & Suspension
Steering gear boot
......................#SN9581.........$11.95
Ball joint, upper
.......................#SN1954.....$39.95
Lower
......................#SN10729..........$39.95
Tie rod
.......................#SN2068.........$69.95
Tie rod end
.......................#SN2072..........$29.95
Bushing, control arm, 2 per
Upper..............#SN9345.........$33.95
Lower............#SN12536..........$16.50
Bushing, front sway bar, outer 21mm bar
.....................#SN14863................$9.95
Rear Brake & Hydraulics
Rear brake drum
.....................#SN2238...........$49.95
Rear wheel cyl., all
......................#SN4603...........$20.00
Rear Bearings & Seals
Rear stub axle
.....................#SN13713..New.............$75.00
Rear stub axle
.....................#SN31189..Used............$50.00
Rear whl brg, inner, all
......................#SN2131.........$23.95
Rear whl brg, outer
......................#SN2129..........$25.95
Rear axle seal, 2 per wheel
........................#SN2132..........$3.50
Rear C/V Axles & Components
Rear driveshaft, 88 on REB
......................#SN12505.. M/T..........$125.00
25X Auto specify L or R
............#SN14183/#SN12506........$129.95
Rear C/V joint
......................#SN2133..........$69.95
Cables, Pedals & Components
Accelerator cable, M/T
........................#SN2464..........$23.95
..........................A/T
.......................#SN11326..........$29.95
Speedometer cable
thru 1987, w/ wrn. sys. Upper
....................#SN36550.............$19.95
...................................Lower
....................#SN13423.............$15.95
Hand brake cable, L/H rear
.....................#SN4403.............$19.95
Pedal pad, brake & clutch
.......................#SN2430..............$1.50
Temperature Controls
Heater switch, blw. mtr
........................#SN3235..........$16.95
Heater val., primary heater
........................#SN2711..........$13.95
Fan Belts
Alt/gen belt, thru 1986, 65A altr, thru
CH # 24G120000, thru 1988, 2nd altr. w/o AC
........................#SN5363............$7.95
90A altr, all, 65A altr, w/o AC
from Ch #24H000001
........................#SN3660..........$12.95
Power steering belt
........................#SN5363............$7.95
A/C belt
.......................#SN3664...........$14.95
Alternator**
'83-85, '88-92
.....................#SN3269..........$169.95
'86-88 Rebuilt
.....................#SN5673..........$169.95
Voltage regulator
.....................#SN10138............$39.95
**Starters and alternators for Vanagon are covered in more detail in another section. They are available as Bosch/Lucas remanufactured, rebuilt and used. There are significant savings from dealer prices.
Ignition
Cap w/o shield (to 88)
.........................#SN3459.........$17.95
Distributor rotor
.........................#SN3465.............$8.95
Ignition coil
.........................#SN4443.........$69.95
Bosch ign. wire set
........................#SN3446..........$72.95
P/U unit, Fuel sender
.......................#SN32733........$45.00
Ignition switch w/loop
.........................#SN3040.........$14.95
tumbler w/keys
.........................#SN3038...................$19.95
Starters**
Bosch Remanufactured
thru 11/86, M/T....#SN3249................$179.95
thru 11/86, A/T.....#SN3248................$189.95
from 12/86, M/T....#SN10995.............$199.95
from 12/86, A/T....#SN12482..............$199.95
WE HAVE GREAT USED STARTERS
Tail Light & Side Marker
Side marker lens, rear
...........................#SN35208...............$10.00
Interior Light Dome light assy.
............................#SN3159..........$9.95
To avoid very expensive corrosion problems with the heads and head studs, always use phosphate free, ethylene glycol, VW approved anti-freeze. We sell it - #SN18727
