Page 115 - VW parts: Steering Racks, Power Steering Pump

Golf III/Jetta III '93-'99 & Cabriolet '95-'02

STEERING

All Golfs, Jettas and Cabrios manufactured from 1993 onward have power assisted rack and pinion steering. Two different manufacturers, ZF and TRW, supplied steering racks and the rods. Unfortunately the two are not interchangeable. When ordering steering parts, you must know which steering rack you have. The easiest way to tell is to pop the hood and look at the rack. If the rack is smooth, it is made by TRW. If the rack has a waffle pattern in the casting it is made by ZF.

(See pictures below).

POWER STEERING RESERVOIR

If you're constantly adding power steering fluid, check for leaks at the pump, the rack and the hoses. If none of these are leaking, it's probably the reservoir. They are plastic and sometimes they do crack.

4 cylinder, all '93-99.5, Cabrio '95-02

#SN16767 . . . . . . . .$39.95

#SN39009 . . . . . . . .$20.00

VR6, all '93-99.5

#SN14198 . . . . . . . .$59.95

#SN38497 . . . . . . . .$25.00

POWER STEERING HOSES

When these fail, you'll notice that you either lose power assist to the steering, you're always adding power steering fluid, your engine compartment is an oily mess or all of the above. There are three main hoses in the system, completing a circuit between the steering, the rack and the reservoir. Call with your needs, we have new hoses and good recycled hoses available.

Return line (from the rack to reservoir)

#SN18832 . . . . . . . .$29.95

Pressure line (from pump to rack)

2.0 L Golf/Jetta

#SN15464 . . . . . . . .$89.95

VR6 Golf/Jetta

#SN15466 . . . . . . . .$275.00

TDI Golf/Jetta

#SN15465 . . . . . . . .$174.95

Cabrio (auto trans)

#SN15465 . . . . . . . .$174.95

Cabrio (manual trans)

#SN18833 . . . . . . . .$174.95

Suction line (from reservoir to pump)

BRAKES

Absolutely no reason exists to skimp on a brake repair. Considering how crucial good brakes are, and how easy they are to replace and how cheap the parts are, your should inspect your brakes regularly and replace them when the pads or linings are worn. If the discs of drums are grooved, it's usually cheaper to replace them, rather than have them turned. If you do your own oil changes, then you should have no problem doing your own brakes. It's easy and you can save a lot of money!

FRONT CALIPERS

4 cylinder, all (2.0 L and TDI)

New #SN14156 . . . . . . . .$109.95

Left

#SN40014 . . . . . . . .$59.95

#SN35578 . . . . . . . .$25.00

Right

#SN40012 . . . . . . . .$59.95

#SN35577 . . . . . . . .$25.00

VR6

'93-95

#SN14157 . . . . . . . .$89.95

#SN14500 . . . . . . . .$119.95

'96-97

#SN18834 . . . . . . . .$189.95

#SN18835 . . . . . . . .$189.95

'98-99.5

#SN18836 . . . . . . . .$149.95

#SN18837 . . . . . . . .$149.95

TECH TIP: A brake job is a big deal at the dealer, but changing front rotors and pads is less than a 2 hour job for the D.I.Y.er, less if you're fast, and JUST AS GOOD!!! Could save you $1,000!!

STEERING RACKS

TRW, all '93-99.5 Recycled

#SN15455 . . . . . . . .$225.00

ZF 4 cylinder, all '93-99.5 Recycled

#SN15456 . . . . . . . .$225.00

ZF 6 cylinder, all '93-99.5 Recycled

#SN36657 . . . . . . . .$250.00

TIE ROD BOOTS

(Left & Right are the same)

TRW rack #SN15754 . . . . . . . .$12.95

ZF rack #SN15690 . . . . . . . .$12.95

TIE RODS

TRW, '93-99.5

#SN13608 . . . . . . . .$49.95

#SN13609 . . . . . . . .$49.95

ZF, '93-99.5

#SN13346 . . . . . . . .$59.95

#SN13347 . . . . . . . .$59.95

POWER STEERING PUMP

If your pump groans or leaks or can no longer provide adequate steering assist, it's time for a new pump. We have new or excellent recycled pumps available.

4 cylinder, 93-95

#SN15458 . . . . . . . .$219.95

#SN37367 . . . . . . . .$89.95

VR6, '93-99.5

#SN15461 . . . . . . . .$274.95

#SN39008 . . . . . . . .$99.99

Power Steering Pump Rebuild Kits . . .Call!

REAR STUB AXLES

If a rear wheel bearing goes bad, you will usually have to replace the stub axle as well. Examine them for scoring any time you remove the rear drums (or discs).

Drum brakes (w/o ABS)

Left/Right

New #SN16170 . . . . . . . .$39.95

Reman #SN13520 . . . . . . . .$19.50

Disc brakes (w/o ABS)

Left

New #SN33382 . . . . . . . .$89.95

Reman #SN12555 . . . . . . . .$65.00

Recycled #SN2116 . . . . . . . .$40.00

Right

New #SN13526 . . . . . . . .$89.98

Reman #SN37116 . . . . . . . .$65.00

Recycled #SN31180 . . . . . . . .$40.00

Disc brakes (w/ ABS)

Left New #SN33382 . . . . . . . .$89.95

Right New #SN13526 . . . . . . . .$89.98

BRAKE PADS (Front)

4 cylinder, all '93-99.5 (Cabrio '95-02)

#SN2354 . . .$29.95

#SN16216 . .$39.95

VR6, '93-95

#SN14155 . . .$49.95

VR6, '96-99.5

#SN18772 . . .$49.95

BRAKE ROTORS (Front)

4 cylinder, all '93-99.5 (Cabrio '95-02)

#SN4698 . . . . . . . .$29.95

VR6

'93-95

#SN10679 . . . . . . . .$39.95

'96-99.5

#SN19696 . . . . . . . .$34.95